1HVBAZRN2LH246556

THE WIRE END OF THE HAND THROTTLE CABLE PASSES THROUGH A SPLIT PLASTIC GROMMET IN THE ACCELERATOR ROD. THIS WIRE CAN WORK THROUGH THE SLOT IN THE GROMMET AND BECOME LODGED BETWEEN THE GROMMET AND THE EDGE OF THE HOLE IN THE ACCELERATOR ROD.

IF THE THROTTLE WIRE BECOMES LODGED, THE ACCELERATOR CAN STICK AND NOT RETURN TO IDLE POSITION POTENTIALLY AFFECTING THE OPERATOR'S ABILITY TO CONTROL THE VEHICLE AND INCREASING THE POTENTIAL FOR AN ACCIDENT.

DEALERS WILL REPAIR BUSES BY INSTALLING A NEW CABLE GROMMET WITHOUT A SLOT; INSTALL A NEW CABLE STOP; AND READJUST THE THROTTLE CABLE.

THE FUEL SYSTEM FAILED THE CRASH BARRIER TEST.

THE FUEL TANK WAS PUNCTURED, RESULTING IN FLUID LOSSGREATER THAN ALLOWED BY FMVSS 301, "FUEL SYSTEM INTEGRITY". FUEL SPILLS INA COLLISION COULD LEAD TO A VEHICLE FIRE IF EXPOSED TO A SOURCE OF IGNITION.

MODIFY THE FUEL TANK CAGE TO COMPLY WITH FMVSS 301.

THE THROTTLE VALVE INSIDE THE HYDRAULIC BRAKE BOOSTER MAY DEFORM FROM BUILDUP OF HEAT AND PRESSURE AND CLOSE-OFF FLUID RETURN PORTS.

THIS COULD CAUSE EXCESSIVE PRESSURE BUILDUP IN THEBOOSTER CAUSING THE BRAKES TO SELF APPLY WITH A SEVERE UNEXPECTED STOP. THISCONDITION COULD ALSO RESULT IN LOSS OF POWER STEERING ASSIST. EITHER CONDITIONCOULD RESULT IN AN ACCIDENT.

REPLACE BRAKE BOOSTER ASSEMBLY.

THESE BUSES HAVE A TURN SIGNAL LEVER THAT WILL NOT OPERATE CONSISTENTLY IN THE LANE CHANGE MODE IF THE LEVER IS NOT MOVED TO THE POSITION WHERE RESISTANCE TO MOVEMENT IS FELT.

SHOULD THE REAR SIGNAL LAMPS NOT FLASH WHEN A LANE CHANGE WAS BEING MADE, IT COULD RESULT IN A VEHICLE FOLLOWING THE BUS TO COLLIDE WITH THE BUS INCREASING THE RISK OF PERSONAL INJURY AND/OR PROPERTY DAMAGE.

OPERATORS WILL BE MAILED INFORMATION CONCERNING THE PROPER METHOD OF USING TURN SIGNALS. A DECAL WILL ALSO BE PROVIDED TO BE PLACED ON THE INSTRUMENT PANEL OF EACH BUS.