1HSHXSBR35J129641

ON CERTAIN TRUCKS, THE BOLTS THAT MOUNT THE FRONT OF THE CAB TO THE MOUNTING BRACKETS WERE NOT PROPERLY TORQUED AT THE MANUFACTURING PLANT.

THESE BOLTS CAN LOOSEN DURING NORMAL VEHICLE USE AND FALL OUT. THIS MAY LEAD TO THE CAB SEPARATING FROM THE VEHICLE'S CHASSIS DURING A VEHICLE CRASH THAT MAY RESULT IN PROPERTY DAMAGE, PERSONAL INJURY OR DEATH.

AS AN INTERIM ACTION, DEALERS WILL PROPERLY TIGHTEN THE EXISTING CAB MOUNTING BOLTS AND REPLACE ANY MISSING BOLTS. AS SOON AS PARTS ARE AVAILABLE, DEALERS WILL REPLACE ALL SIXTEEN BOLTS AND TIGHTEN THEM PROPERLY. AN INTERIM LETTER WAS SENT TO OWNERS ON FEBRUARY 11, 2005. ANOTHER LETTER WAS SENT TO OWNERS ON APRIL 8, 2005, AS SOON AS PARTS ARE AVAILABLE. OWNERS SHOULD CONTACT INTERNATIONAL AT 1-800-448-7825.

ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH CATERPILLAR DIESEL ENGINES, THE ENGINE ELECTRICAL GROUND CABLE THAT CONNECTS THE ENGINE BLOCK WITH THE STARTER MAY BE ROUTED IN A WAY THAT COULD CAUSE CHAFING AGAINST THE STARTER'S POSITIVE BATTERY CABLES.

IF CHAFING OCCURS BETWEEN THE POSITIVE AND NEGATIVE CABLES, AN ELECTRICAL SHORT MAY RESULT AND MAY CAUSE A VEHICLE FIRE, POSSIBLY RESULTING IN PROPERTY DAMAGE, PERSONAL INJURY OR DEATH.

DEALERS WILL INSPECT THE ENGINE GROUND CABLES FOR PROPER ROUTING. IF ANY CHAFING IS FOUND, THE ENGINE BLOCK GROUND CABLE WILL BE REPLACED WITH A SHORTER (280MM) CABLE AND ANY OTHER DAMAGED CABLES WILL BE REPLACED AND ROUTED CORRECTLY FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 21, 2005. OWNERS MAY CONTACT INTERNATIONAL AT 1-800-448-7825.

ON CERTAIN VEHICLES EQUIPPED WITH AIR OPERATED FIFTH WHEEL SLIDES AND AN MSVA 7-PACK ACCESSORY CONTROLLER, THE 7-PACK CAN ALLOW WATER TO CONTAMINATE ITS CIRCUIT BOARD. THIS COULD RESULT IN INADVERTENT OPERATION OF THE FIFTH WHEEL SLIDE CONTROL.

IF THE SLIDE CONTROL ACTUATES WHILE THE VEHICLE IS IN MOTION, MOMENTUM FROM THE TRAILER CAN CAUSE THE FIFTH WHEEL TO SLIDE WITHOUT INPUT FROM THE DRIVER, WHICH COULD RESULT IN A CRASH WITHOUT WARNING.

DEALERS WILL RELOCATE THE MSVA 7-PACK TO A LESS WATER INTENSIVE ENVIRONMENT. A NEW MSVA 7-PACK BASE, THAT HAS BEEN IMPROVED TO PREVENT WATER INTRUSION, AND ALL AIR ACCESSORY SOLENOIDS WILL BE INSTALLED FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 5, 2005. OWNERS MAY CONTACT INTERNATIONAL AT 1-800-448-7825.

Navistar, Inc. (Navistar) is recalling certain 2000-2003 International 8100, 2001-2003 International 9100i, 2001-2007 International 9400i, 2001-2010 International 9200i, 2002-2007, 2009 International 8500, 2003-2007, 2013 International 9900i, 2003-2018 International 8600, 2004, 2007 International 9900iX, 2008-2018 International ProStar, 2010-2011, 2013, 2016 International LoneStar, 2011-2012, 2016 International 4400, 2017-2024 International LT, 2018-2024 International RH, 2019-2021 International LS, 2019-2024 International MV vehicles. The back-up lights offer low visibility when the vehicle is in reverse and bobtail mode. Also, the vehicles have not been equipped with additional unobstructed back-up lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."

Low visibility or obstructed back up lights may not alert other drivers that the vehicle is backing up, increasing the risk of a crash.

Dealers will replace the existing rear stop/turn signal lights, free of charge. Owner notification letters were mailed May 06, 2024. Owners may contact Navistar's customer service at 1-800-448-7825. Navistar's number for this recall is 23514.