VIN 1GNFK16K3NJ330307

THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 1992-1994 CHEVROLET AND GMC SUBURBANS EQUIPPED WITH VACUUM POWER-BRAKE ASSIST AND EBC4 ANTI-LOCK BRAKE (ABS) MODULES. THESE VEHICLES EXHIBIT POOR BRAKE SYSTEM PERFORMANCE.

THIS COULD BE ATTRIBUTED TO BRAKE PEDAL FEEL.

DEALERS WILL INSTALL A NEW BRAKE PEDAL PAD. IN ADDITION, DEALERS WILL INSPECT THE BRAKE-BOOSTER OUTPUT ROD AND REPLACE IT IF NECESSARY.

CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.

THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.

HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).

THE PIVOT BOLT HOLDING THE BRAKE PEDAL TO ITS SUPPORT BRACKET MAY BE IMPROPERLY TIGHTENED AND MAY NOT HAVE ENGAGED THE LOCKING MATERIAL ON THE BOLT. THE BOLT CAN DISENGAGE FROM THE NUT.

IF THE PIVOT BOLT DISENGAGES FROM THE NUT WHILE THEVEHICLE IS IN MOTION, THERE WILL BE A LOSS OF BRAKE CONTROL AND COULD RESULT INA VEHICLE ACCIDENT.

DEALERS SHOULD INSPECT THE HAND STARTED BRAKE PEDAL BOLTS AND TORQUE THEM TO SPECIFICATION.

UNANTICIPATED HEAT IN THE TRANSMISSION CAN FORCE THE TRANSMISSION FLUID OUT OF THE VENT TUBE.

THE VENTED TRANSMISSION FLUID CAN CATCH FIRE IF EXPOSEDTO A SOURCE OF IGNITION.

INSTALL A LONGER TRANSMISSION VENT HOSE ROUTED TO THE LEFT SIDE OF THE ENGINE COMPARTMENT OF THE VEHICLE.

SEVERE CORROSION DUE TO ROAD SALT AT THE JOINT OF THE STAMPED STEEL CENTER SECTION AND THE CAST OUTER SECTION CAN CAUSE THE SECTIONS TO SEPARATE.

SEPARATION OF THE ROTOR SECTIONS CAN CAUSE LOSS OFBRAKING ABILITY IN THE AFFECTED WHEEL. THIS COULD RESULT IN INCREASED STOPPINGDISTANCE AND/OR LOSS OF VEHICLE CONTROL AND AN ACCIDENT.

REPLACE THE FRONT BRAKE ROTORS WITH NEW ROTORS WITH A CORROSION PROTECTION COATING. HOWEVER, IF REPLACEMENT OF BRAKE LININGS ARE NECESSARY, IT WILL BE DONE AT OWNER'S EXPENSE SINCE BRAKE LININGS ARE NORMAL MAINTENANCE ITEMS.